:::

詳目顯示

回上一頁
題名:鉛酸電池最佳化充電技術之研究
作者:陳德超
作者(外文):Te-Chau Chen
校院名稱:國立彰化師範大學
系所名稱:工業教育學系
指導教授:陳財榮
學位類別:博士
出版日期:2004
主題關鍵詞:田口方法鉛酸電池最佳化充電參數灰關聯分析多重品質特性Taguchi methodlead-acid batteryoptimal charging parametersgrey relation analysismultiple quality characteristics
原始連結:連回原系統網址new window
相關次數:
  • 被引用次數被引用次數:期刊(0) 博士論文(0) 專書(0) 專書論文(0)
  • 排除自我引用排除自我引用:0
  • 共同引用共同引用:0
  • 點閱點閱:30
本文之研究目的在探討最佳化充電技術,應用量測系統進行鉛酸電池充放電資料收集與分析,量測系統由個人電腦、電源供應器、電子負載及數位電表所構成,採用四段定電流充電,利用田口方法依所設計直交表來進行實驗,並以平均值分析與S/N(訊號雜訊比)比分析個別求出實驗結果及比較所得結果之完整性,以預測值分析法判斷及求出各品質特性(充電時間、充入容量)下的四段定電流因子水準最佳組合,再以灰關聯分析法來解決多重品質特性之充電時間與充電效率的衝突問題,以求出一組最佳化的充電參數組合。
A study of optimized charge technique has reported in this dissertation. The measurement system hardware for sampling and analyzing the charge-discharge data of lead-acid battery include personal computer (PC), power supply, electronic load, and digital electronic meter. The measurement approach uses four-step constant current charging, and utilizes the orthogonal table of the Taguchi method to obtain experimental analysis of mean value and signal noise ratio. Comparing the experimental analysis, we obtain the complete of experimental result and use the predication analysis to extract the best combination of four-step constant current charging with single quality characteristic (charging time or charging capacity). For multiple quality characteristics, grey relation analysis can solve trade-off problem of charging time and charging efficiency to extract the optimized combination of the charging parameters.
[1] P. H. Cheng and C. L. Chen, "High Efficiency and Nondissipative Fast Charging Strategy," Proceedings of IEE Electric Power Applications, Vol. 150, No. 5, pp. 539-545, 2003.
[2] P. M. Hunter and A. H. Anbuky, "VRLA Battery Rapid Charging Under Stress Management," IEEE Trans. on Industrial Electronics, Vol. 50, No. 6, pp. 1229-1237, 2003.
[3] E. Koutroulis and K. Kalaitzakis, "Novel Battery Charging Regulation System for Photovoltaic Applications," Proceedings of IEE Electric Power Applications, Vol. 151, No. 2, pp. 191-197, 2004.
[4] N. K. Poon, B. M. H. Pong and C. K. Tse, "A Constant-Power Battery Charger with Inherent Soft Switching and Power Factor Correction," IEEE Trans. on Power Electronics, Vol. 18, No. 6, pp. 1262-1269, 2003.
[5] C. F. Chuang, T. R. Chen and T. C. Chen, "Optimization of Lead-Acid Battery Charging for Small Uninterrupted Power Supply (UPS)," Proceedings of the National Science Council (Part A), Vol. 25, No. 6, pp.377-383, Nov. 2001.
[6] T. R. Chen, T. C. Chen and C. F. Chuang, "Study of Charging Characteristics for Small Capacity Lead-Acid Battery," International Conference on Power and Energy Systems (EuroPES2001), pp. 615-620, Rhodes, Greece, July 3-6, 2001.
[7] T. R. Chen, T. C. Chen, C. F. Chuang and F. C. Liu, "Study of Battery Charging Characteristics for Electric Vehicles," International Conference on Power and Energy Systems (EuroPES2001), pp. 626-630, Rhodes, Greece, July 3-6, 2001.
[8] C. L. Lin, W. D. Chou and J. L. Lin, "Optimization of the Electrical Discharge Machining Process Bassed on the Taguchi Method with Fuzzy Logics," Journal of Science and Technology, Vol. 10, No. 2, pp. 119-127, 2001.
[9] N. Logothetis and A. Haigh, "Characterizing and Optimizing Multi-Response Processes by the Taguchi Method," Quality and Reliability Engineering International, Vol. 4, No. 2, pp. 159-169, 1988.
[10] Y. S. Tarng and W. H. Yang, "Application of the Taguchi Method to the Optimization of the Submerged arc Welding Process," Materials and Manufacturing Processes, Vol. 13, No. 3, pp. 455-467, 1998.
[11] C. B. Chen, C. T. Lin, C. W. Chang and C. P. Ho, "Grey Relation for Solving Multi-quality Characteristics Problems of Taguchi Methods," Journal of Technology, Vol. 15, No. 1, pp. 25-33, 2000.
[12] M. H. Moody, "A High Reliability Battery Management System," Journal of Power Sources, Vol. 18, pp. 223-231, 1986.
[13] E. V. Kassick and I. Barbi, "A Low Cost High Power Factor Resonant Mode Battery Charger," Applied Power Electronics Conference, pp. 543-548, 1993.
[14] W. Koczara and P. Bialoskorski, "Multilevel Boost Rectifiers as a Unity Power Factor Supply for Power Electronics Drive and for Battery Charger," IEEE International Symposium on Industrial Electronics, pp. 477-481, 1993.
[15] D. M. Sable, et. al., "A Zero-Voltage-Switching Bidirectional Battery Charger/Discharger for the NASA EOS Satellite," IEEE Conference on Applied Power Electronics, pp. 614-621, 1992.
[16] C. E. Lin, C. C. Chieng and J. J. Chang, "A High Efficiency Ni-Cd Battery Charger Using Stepwise Monitoring," IEEE IECON, pp. 2461-2465, 1991.
[17] T. Palanisamy, "Charging Techniques for a Universal Lead-Acid Battery Charger," IEEE Proceedings of the 34th International Power Sources Symposium, pp. 72-76, 1990.
[18] Milton Wolpow Phase Electronics, "Ring Battery Charger, by Individual Cell or Group of Three Cells for Discharge Capacity Enhancement," Intelec., pp. 134-137, 1990.
[19] T. F. Vescovi and N. C. H. Vun, "A Switched-Mode 200A 48V Rectifier/Battery Charger for Telecommuni-
cations Applications," Intelec., pp. 112-118, 1990.
[20] R. L. Steigerwald, "Pulse Battery Charger Employing 1000 Ampere Transistor Switches," IEEE Ind. Appl. Soc. Meet., Vol. 2, pp. 1127-1132, 1977.
[21] M. H. Katz, T. C. Adler, F. R. McLarnon and E. J. Cairns, "The Effect of Pulse Charging on the Cycle Life Performance of Zinc/Nickel Oxide Cells," J. of Power Sources, Vol. 22, pp. 77-95, 1988.
[22] S. T. Hung, D. C. Hopkins and C. R. Mosling, "Extension of Battery Life via Charge Equalization Control," IEEE Trans. on Industrial Electron., Vol. 40, No.1, pp. 96-104, Feb. 1993.
[23] R. F. Nelson, "The Advanced Lead-Acid Battery Consortium an Overview," Proceedings of the 9th Annual Battery Conference on Applications and Advances, pp. 28-9, Jan. 1994.
[24] K. W. Klontz, et. al., "An Electric Vehicle Charging System with 'Universal' Inductive Interface," Conference Record of the Power Conversion Conference Yokohama 1993, pp. 227-232, April 1993.
[25] J. H. Aylor, A. Thieme and B.W. Johnson, "A Battery State-of-Charge Indicator for Electric Wheelchairs," IEEE Trans. on Industrial Electron., Vol. 39, No. 5, pp. 398-409, Oct. 1992.
[26] G. L. Tsay, T. R. Chen, J. J. Chen and J. W. Lin, "Studies of the Battery Charger," Proceedings of the 17th Symposium on Electrical Power Engineering, pp. 777-782, Nov. 8-9, 1996.
[27] T. R. Chen and G. L. Tsay, "Implementation of the Battery Charger with High Power Factor and High Efficiency," Proc. of the 16th Symposium on Electrical Power Engineering, pp. 299-303, Nov. 24-25, 1995.
[28] 陳財榮、林建文,充電器電源電路,電子月刊第28期,民國86年11月,頁60~66。
[29] T. R. Chen, J. W. Lin, G. L. Tsay and J. J. Chen, "A Microprocessor Controlled Battery Fuel Gauge and Charger," The Second Symposium on Computer and Communication Technology Proceedings 1996, pp. 221-225, Oct. 4, 1996.
[30] M. Inaniwa, S. Suzuki and Y. Ogawa, "Circuit Arrangement for Rapidly Charging a Battery," U.S. Pat. No.4609861, Sep. 2, 1986.
[31] K. G. Horn, "Process for Charging Maintenance-Free Lead Batteries with a Fixed Electrolyte," U.S. Pat. No.4952861, Aug. 28, 1990.
[32] K. Shimomoto, "Battery Charging Method and Apparatus Using Initial Charging Step with Gradually Increasing Charging Current, Quick Charging Step with Large Charging Current and Final Charging Step with Decreasing Charging Current," U.S. Pat. No. 5500584, Mar. 19, 1996.
[33] F. G. Broell, J. Parvereshi and S. P. Sacarisen, "Lead Acid Charger," U.S. Pat. No.5710506, Jan. 20, 1998.
[34] 沈宗福、劉瑤,電動車的充電方法及其車上型充電裝置,中華民國專利公告編號:259901,民國84年10月11日。
[35] 玉井幹隆、雨堤徹,二次電池之充電方法,中華民國專利公告編號:271470,民國85年3月1日。
[36] 岩佐貞之、影山雄一,二次電池的充電方法及充電裝置,中華民國專利公告編號:370733,民國88年9月21日。
[37] 湯淺電池產品說明手冊。
[38] 梁適安 編,交換式電源供應器之理論與實務設計,全華圖書,台北市,民國88年10月,頁7~199。
[39] 梁適安 譯,高頻交換式電源供應器原理與設計,全華圖書,台北市,民國84年,頁10~200。
[40] Power Integrations, Inc., "Constant Current/Constant Power Regulation Circuits for TOPSwitch," DN-14, 1996.
[41] 鄭培璿 編,Is Spice 在電力電子與電源轉換器上的應用,全華圖書,台北市,民國89年6月。
[42] H. A. Kiehne, INC., "Battery Technology Handbook," Expert Verlag, Germany, 1989.
[43] N. R. Pinsky, et al., "Fast Charge of Lead Acid Batteries at the SCE EV Tech. Center", Battery Conference on Applications and Advances, The 15th Annual pp. 231-236, 1999.
[44] I. Tomohiko, et al., "Multi-Step Constant-Current Charging Method of Electric Vehicle, Valve-Regulated
,Lead/Acid Batteries During Might Time for Load-Levelling", Journal of Power Sourses, Vol. 75, No. 1, pp. 101-107, 1998.
[45] S. C. Kim, and W. H. Hong, "Fast-Charging of a Lead-Acid Cell: Effect of Rest Period and Depolarization Pulse", Journal of Power Sources, Vol. 89, pp. 93-101, 2000.
[46] 鍾翼能、曾國境、孫育義,三階段充電系統之研製,中華民國第十九屆電力工程研討會,民國87年,頁115~120。
[47] 華志強、林孟郁,電動車電池充電儲能監視系統,第十五屆全國技術及職業教育研討會論文集,工業類電機組,民國89年,頁1~9。
[48] 陳友忠、吳成有,鉛酸電池快速充電參數效應暨最佳化研究,台電工程月刊第626期,民國89年,頁98~106。
[49] 黎正中 編,穩健設計之品質工程,台北圖書,台北市,民國82年6月。
[50] 陳啟斌、林進財、張哲維,灰關聯應用於解田口方法多重品質特性問題,技術學刊,第5期,第1卷,民國89年,頁25~33。
[51] 唐麗英、王春和,應用灰色關聯分析法於動態系統具多品質特性製程最佳化之研究,工業工程學刊,第17期,第2卷,民國89年,頁147~156。new window
[52] 張偉哲、溫坤禮、張廷政,灰關聯模型方法與應用,高立圖書有限公司,民國89年。
[53] J. H. Wu, "An Alternative Form for Grey Relational Grades," The Journal of Grey System 1, pp. 7-12, 1999.
 
 
 
 
第一頁 上一頁 下一頁 最後一頁 top